International |
|
|
|
|
|
Features |
|
• | Provides ON-OFF switched control of a directly connected load. |
|
|
• | Meets the requirements of Outdoor/Indoor (IP67, Type 3R, 4X, Watertight, Corrosion resistant) and Indoor (Type 12K Dust tight) installations. |
|
|
• | This enclosure provides lockout capability in compliance with OSHA Lockout/Tagout Regulation 29 CFR Part 1910.147 (in the OFF position) with an acceptable padlock/shackle, thereby assuring the connected equipment cannot be energized. |
|
|
• | Auxiliary contact open prior to the line contacts for pilot duty switching. |
|
|
NOTE: This enclosure must not be used as a junction box for feed-through connections. |
|
|
|
|
|
|
|
Catalog Number: 5100MI9W |
|
Mechanical Interlock North American Pin and Sleeve Receptacle, 100 Amp, 120/208 Volt 3PhY, IEC 60309-1 and IEC 60309-2, 4-POLE, 5-WIRE, Industrial Grade, IP67, Watertight, Non-Fused, BLUE, (Liquid-tight conduit fitting can be installed for top or bottom feed using Catalog No. HUB-200 sold separately) |
|
• |
|
|
| Hub Sold Separately: HUB-200 |
Product image |
Catalog No. and Description |
|
Stock |
|
Watertight Conduit Hub, 3/4" - For use with IMC (Intermediate Metal Conduit) or rigid conduit; threaded connection type |
|
|
|
Watertight Conduit Hub, 1" - For use with IMC (Intermediate Metal Conduit) or rigid conduit; threaded connection type |
|
|
|
Watertight Conduit Hub, 1-1/2" - For use with IMC (Intermediate Metal Conduit) or rigid conduit; threaded connection type |
|
|
|
Watertight Conduit Hub, 1-1/4" - For use with IMC (Intermediate Metal Conduit) or rigid conduit; threaded connection type |
|
|
|
Watertight Conduit Hub, 2" - For use with IMC (Intermediate Metal Conduit) or rigid conduit; threaded connection type |
|
|
|
Select desired product above to get further informations. Non stock products have a minimum order quantity. |
|
|
|
|
|
|
Technical Information |
|
AC Horsepower Ratings |
At Rated Voltage | 25 HP |
|
Electrical Specifications |
Amperage | 100 Amp |
Voltage | 120/208 Volt 3PhY |
Pole | 4 |
Wire | 5 |
Current Interrupting | Certified for current interrupting at full rated current |
Endurance | 6000 cycles inductive motor type load |
Dielectric Voltage | 1000V plus rated voltage for 1-minute |
|
Environmental Specifications |
Flammability | No 0.6; V-0 for watertight enclosure |
Rain | Type 3R per UL 50 |
Hosedown | Type 4X per UL 50 |
Dust | Type 12K per UL 50 |
Gasket Aging | 70°C for 168 hours |
UV Resistance | Exposed plastic materials are UV stabilized |
Operating Temperature | -40°C to +60°C |
|
Material Specifications |
Housing Material | Valox 357 |
Cover with Arm | Valox 357 |
Locking Ring | Valox 357 |
Cover Eyelet | Nickel-Plated Brass |
Gasket Material | Chloroprene |
Handle Material | Valox 357 |
Actuator Material | Zinc-Coated Steel |
Locking Mechanism | Valox 357 |
Contact Carrier | Nylon |
Phase and Ground Sleeves | Brass |
Ground Contacts | Brass |
Conduit Grounding Plate | Zinc-Coated Steel |
Switch Material | Reinforced Nylon |
Switch Terminal Contacts | Brass |
Switch Contacts | Cadmium-Free Silver Alloy |
Internal Screws | Zinc-plated steel |
Housing Screws | Stainless Steel |
Ground Terminal | Plated Brass/Steel |
Ground Terminal Block | Nylon |
Neutral Terminal | Plated Brass/Steel |
Neutral Terminal Block | Nylon |
Terminal Shaft Key | Die-Cast Aluminum |
|
Mechanical Specifications |
Mold Stress Relief | 70°C for 7 hours |
Crush Test | 100 lbs |
Impact | 1.2 lb ball dropped from 5 ft |
Cold Impact | Same as above, after conditioning to -35°C |
Strength of Insulating Base and Support | 110% of specified tightening torque on terminal screws |
Pullout | 18 lb pull on internal wires |
|
Product Features |
Color | Blue |
|
Standards and Certifications |
UL | 231 and 1686 |
UL 508 | Non-Fused |
CSA | C22.2 |
CE Marking | Per low voltage directives 73/23/EEC, 93/68/EEC |
IEC Rating | 60309-1 and 60309-2 |
|
|
|
Nominal Dimensions |
|
|
Nominal Dimensions: inch (mm) – Refers to mechanical interlocks 60 amp fuse versions and 100 amp non-fused versions. |
|
|
Specifications and information are nominal and are subject to change without notice.